Volume 8 Issue 4
Jul.  2018
Turn off MathJax
Article Contents
Article Navigation >  Journal of Environmental Engineering Technology  > 2018  >  8(4): 435-442
LI Xiaoguang, ZHAO Ying, KANG Dejun, YANG Tianxue, GONG Bin, ZHANG Ying, LIU Jiaomei, JOW Jinder, ZENG Yuping. Study on phosphorus removal from biogas slurry by red mud[J]. Journal of Environmental Engineering Technology, 2018, 8(4): 435-442. doi: 10.3969/j.issn.1674-991X.2018.04.057
Citation: LI Xiaoguang, ZHAO Ying, KANG Dejun, YANG Tianxue, GONG Bin, ZHANG Ying, LIU Jiaomei, JOW Jinder, ZENG Yuping. Study on phosphorus removal from biogas slurry by red mud[J]. Journal of Environmental Engineering Technology, 2018, 8(4): 435-442. doi: 10.3969/j.issn.1674-991X.2018.04.057
shu

Study on phosphorus removal from biogas slurry by red mud

doi: 10.3969/j.issn.1674-991X.2018.04.057

  • 1. National Institute of Clean-and-Low-Carbon Energy(NICE), Beijing 102211, China
    2. Chinese Research Academy of Environmental Sciences, Beijing 100012, China
    3. Fuzhou University, Fuzhou 350108, China
    4. Shanghai Institute of Ceramics, Chinese Academy of Sciences, Shanghai 200050, China;

  • Received Date: 2018-02-05
  • Publish Date: 2018-07-20
    Abstract
  • The red mud(RM), an industrial waste of alumina production, was applied to remove phosphorus from biogas slurry. The XRF, XRD, PSD and SEM tests were employed to assess the physicochemical properties of RM. Some important parameters that affect the phosphorus removal efficiency and final pH of solution(pHf), such as initial pH(pHi), RM dosage, reaction time and phosphate concentration of biogas slurry were explored. The results indicated that the phosphate removal efficiency decreased first, and then increased with the increase of pH. And the highest and the lowest phosphate removal efficiency were 89.6% and 47.2%, under the conditions of pHi 2.1 and 6.9, respectively. The RM dosage and contact time had a positive effect, whereas initial phosphate concentration had a negative effect on phosphate removal and pHf. The effects of individual variables on phosphate removal were determined by using a 3 4 orthogonal experiment design. The results showed that the optimal reaction conditions were as follows: pHi 10.0, RM dosage 5.0 g/L, initial phosphate concentration 1.7 mg/L, and contact time 40 min.

     

    • FullText(HTML)
  • loading
    • References(29)
  • [1]
    HAN C, WANG Z, YANG H , et al. Removal kinetics of phosphorus from synthetic wastewater using basic oxygen furnace slag[J]. Journal of Environmental Sciences, 2015,30:21-29.
    doi: 10.1016/j.jes.2014.11.003 pmid: 25872706
    [2]
    QIU L, ZHENG P, ZHANG M , et al. Phosphorus removal using ferric-calcium complex as precipitant:parameters optimization and phosphorus-recycling potential[J]. Chemical Engineering Journal, 2015,268:230-235.
    doi: 10.1016/j.cej.2014.12.107
    [3]
    LÜRLING M, WAAJEN G, van OOSTERHOUT F . Humic substances interfere with phosphate removal by lanthanum modified clay in controlling eutrophication[J]. Water Research, 2014,54:78-88.
    doi: 10.1016/j.watres.2014.01.059 pmid: 24565799
    [4]
    周艳伟, 易莹, 谢乔光 , 等. 沼液中磷的去除与回收技术研究进展[J]. 安徽农业科学, 2014,42(30):10701-10704.
    doi: 10.3969/j.issn.0517-6611.2014.30.095

    ZHOU Y W, YI Y, XIE Q G , et al. Research progress of phosphorus pemoval and pecovery from the digested effluent[J]. Journal of Anhui Agricultural Sciences, 2014,42(30):10701-10704. doi: 10.3969/j.issn.0517-6611.2014.30.095
    [5]
    LIU J, SU Y, LI Q , et al. Preparation of wheat straw based superabsorbent resins and their applications as adsorbents for ammonium and phosphate removal[J]. Bioresource Technology, 2013,143:32-39.
    doi: 10.1016/j.biortech.2013.05.100 pmid: 23786713
    [6]
    YANG S, ZHAO Y, CHEN R , et al. A novel tablet porous material developed as adsorbent for phosphate removal and recycling[J]. Journal of Colloid and Interface Science, 2013,396:197-204.
    doi: 10.1016/j.jcis.2012.12.077 pmid: 23484953
    [7]
    PITAKTEERATHAM N, HAFUKA A, SATOH H , et al. High efficiency removal of phosphate from water by zirconium sulfate-surfactant micelle mesostructure immobilized on polymer matrix[J]. Water Research, 2013,47(11):3583-3590.
    doi: 10.1016/j.watres.2013.04.006 pmid: 23726694
    [8]
    BARAT R, MONTOYA T, SECO A , et al. Modelling biological and chemically induced precipitation of calcium phosphate in enhanced biological phosphorus removal systems[J]. Water Research, 2011,45(12):3744-3752.
    doi: 10.1016/j.watres.2011.04.028 pmid: 21565382
    [9]
    OEHMEN A, CARVALHO G, LOPEZ-VAZQUEZ C M ,et al. Incorporating microbial ecology into the metabolic modelling of polyphosphate accumulating organisms and glycogen accumulating organisms[J]. Water Research, 2010,44(17):4992-5004.
    doi: 10.1016/j.watres.2010.06.071 pmid: 20650504
    [10]
    CHOI J W, LEE S Y, LEE S H , et al. Adsorption of phosphate by amino-functionalized and co-condensed SBA-15[J]. Water,Air & Soil Pollution, 2012,223(5):2551-2562.
    doi: 10.1007/s11270-011-1047-7
    [11]
    LIU J, SU Y, LI Q , et al. Preparation of wheat straw based superabsorbent resins and their applications as adsorbents for ammonium and phosphate removal[J]. Bioresource Technology, 2013,143:32-39.
    doi: 10.1016/j.biortech.2013.05.100 pmid: 23786713
    [12]
    SONG X, PAN Y, WU Q , et al. Phosphate removal from aqueous solutions by adsorption using ferric sludge[J]. Desalination, 2011,280(1):384-390.
    doi: 10.1016/j.desal.2011.07.028
    [13]
    CHEN J, KONG H, WU D , et al. Phosphate immobilization from aqueous solution by fly ashes in relation to their composition[J]. Journal of Hazardous Materials, 2007,139(2):293-300.
    doi: 10.1016/j.jhazmat.2006.06.034 pmid: 16860931
    [14]
    ZHAO Y, ZHANG L, NI F , et al. Evaluation of a novel composite inorganic coagulant prepared by red mud for phosphate removal[J]. Desalination, 2011,273(2):414-420.
    doi: 10.1016/j.desal.2011.01.065
    [15]
    ZHAO Y, WANG J, LUAN Z , et al. Removal of phosphate from aqueous solution by red mud using a factorial design[J]. Journal of Hazardous Materials, 2009,165(1):1193-1199.
    doi: 10.1016/j.jhazmat.2008.10.114 pmid: 19091463
    [16]
    NI F, HE J, WANG Y , et al. Preparation and characterization of a cost-effective red mud/polyaluminum chloride composite coagulant for enhanced phosphate removal from aqueous solutions[J]. Journal of Water Process Engineering, 2015,6:158-165.
    doi: 10.1016/j.jwpe.2015.04.003
    [17]
    ZHAO Y, WANG J, LIU C , et al. Characterization and risk assessment of red mud derived from the sintering alumina process[J]. Fresenius Environmental Bulletin, 2009,18(6):989-993.
    [18]
    BURKE I T, MAYES W M, PEACOCK C L , et al. Speciation of arsenic,chromium,and vanadium in red mud samples from the Ajka spill site,Hungary[J]. Environmental Science & Technology, 2012,46(6):3085-3092.
    doi: 10.1021/es3003475 pmid: 22324637
    [19]
    ZHANG S, LIU C, LUAN Z , et al. Arsenate removal from aqueous solutions using modified red mud[J]. Journal of Hazardous Materials, 2008,152(2):486-492.
    doi: 10.1016/j.jhazmat.2007.07.031 pmid: 17826896
    [20]
    SUSHIL S, BATRA V S . Catalytic applications of red mud,an aluminium industry waste:a review[J]. Applied Catalysis B:Environmental, 2008,81(1):64-77.
    doi: 10.1016/j.apcatb.2008.06.001
    [21]
    WANG S, BOYJOO Y, CHOUEIB A , et al. Removal of dyes from aqueous solution using fly ash and red mud[J]. Water Research, 2005,39(1):129-138.
    doi: 10.1016/j.watres.2004.09.011 pmid: 15607172
    [22]
    ARNOLD E . Standard methods for the examination of water and wastewater[M]. 16th ed.New York:American Public Health Association, 1985: 445-446.
    [23]
    IMAMOGLU M, TEKIR O . Removal of copper(Ⅱ)and lead(Ⅱ)ions from aqueous solutions by adsorption on activated carbon from a new precursor hazelnut husks[J]. Desalination, 2008,228(1/2/3):108-113.
    doi: 10.1016/j.desal.2007.08.011
    [24]
    王东升, 汤鸿霄 . 聚铁硅型复合无机高分子絮凝剂的形态分布特征[J]. 环境科学, 2001,22(1):94-97.
    doi: 10.3321/j.issn:0250-3301.2001.01.023

    WANG D S, TANG H X . Characterization of speciation distribution of IPF-PFSi[J]. Environmental Science, 2001,22(1):94-97. doi: 10.3321/j.issn:0250-3301.2001.01.023
    [25]
    邢赜, 陈玉成, 熊佰炼 , 等. 不同沸石材料对沼液中磷素静态吸附去除[J]. 环境工程学报, 2013,7(2):494-500.

    XING Z, CHEN Y C, XIONG B L , et al. Static adsorption characteristics and removal efficiency of phosphate in biogas slurry by different zeolite substrates[J]. Chinese Journal of Environmental Engineering, 2013,7(2):494-500.
    [26]
    HAGHSERESHT F, WANG S, DO D d . A novel lanthanum-modified bentonite,phoslock,for phosphate removal from wastewaters[J]. Applied Clay Science, 2009,46(4):369-375.
    doi: 10.1016/j.clay.2009.09.009
    [27]
    CAN M Y, YILDIZ E . Phosphate removal from water by fly ash:factorial experimental design[J]. Journal of Hazardous Materials, 2006,135(1):165-170.
    doi: 10.1016/j.jhazmat.2005.11.036 pmid: 16359787
    [28]
    LIU C J, LI Y Z, LUAN Z K , et al. Adsorption removal of phosphate from aqueous solution by active RM[J]. Journal of Environmental Sciences, 2007,19(10):1166-1170.
    doi: 10.1016/S1001-0742(07)60190-9 pmid: 18062412
    [29]
    盛骤, 谢式千, 潘城毅 . 概率论与数理统计[M]. 北京: 高等教育出版社, 2008.
    • Relative Articles
    • Supplements(0)
    • Cited By
  • 加载中

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索
    Get Citation
    PDF
    XML

    Article Metrics

    Article Views(615) PDF Downloads(444) Cited by()
    Proportional views
    Related

    Copyright © Editorial Department of Journal of Environmental Engineering Technology

    京ICP备05031605号-2

    Supported by: Beijing Renhe Information Technology Co., Ltd.  

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return