基于车载测试的轻型汽车排放特征

陈婷; 何潇; 陈文倩; 颜敏; 徐光仪; 郑轩

doi:10.12153/j.issn.1674-991X.20210256

基于车载测试的轻型汽车排放特征

doi: 10.12153/j.issn.1674-991X.20210256

陈婷^1,,
何潇¹,
陈文倩¹,
颜敏²,
徐光仪³,
郑轩^1, ,

1.
深圳大学化学与环境工程学院
2.
深圳市环境科学研究院
3.
河北省环境科学研究院

基金项目: 国家自然科学基金项目（51978404）

详细信息

作者简介:
陈婷(1997—)，女，硕士，主要研究方向为机动车尾气有机物排放特征，chentingcjp@163.com

通讯作者:
郑轩(1983—)，男，研究员，主要从事机动车排放特征与控制策略研究，x-zheng11@szu.edu.cn

中图分类号: X51
计量
- 文章访问数: 296
- HTML全文浏览量: 176
- PDF下载量: 27
- 被引次数: 0
出版历程
- 收稿日期: 2021-08-13

Emission characteristics of light-duty vehicles based on portable emission measurement system (PEMS)

1.
College of Chemistry and Environmental Engineering, Shenzhen University
2.
Shenzhen Academy of Environmental Sciences
3.
Hebei Provincial Academy of Environmental Sciences

摘要

摘要:
选择11辆轻型汽车作为研究对象，利用车载测试系统（portable emission measurement system，PEMS）研究了轻型汽车气态污染物排放和油耗特征。结果表明：轻型汽车一氧化碳（carbon monoxide，CO）、氮氧化物（nitrogen oxides，NO_x）和总碳氢化合物（total hydrocarbons，THC）的排放因子分别为（910.4±822.6）、（58.0±48.3）和（21.6±16.1）mg/km，且其排放速率随发动机比功率-速度（vehicle specific power-velocity，VSP-v）增大而增加，冷启动期间CO、NO_x和THC的排放量占排放总量的11.2%±2.1%、3.7%±5.4%和52.7%±4.6%。轻型汽车瞬态油耗速率随VSP-v的增大而增加，车辆相对油耗在平均车速低于15 km/h时显著上升，车速在40 km/h以上时油耗随车速变化呈平稳的趋势。20 ℃时CO、NO_x和THC排放速率高于1 ℃时的排放速率；1 ℃的环境温度使油耗速率增加，尤其在车辆高速行驶时，1 ℃时其油耗速率比20 ℃时高27.1%±24.5%。
- 轻型汽车 /
- 气态污染物 /
- 油耗 /
- 喷油方式 /
- 冷启动 /
- 行驶工况 /
- 环境温度
Abstract:
The emission characteristics of gaseous pollutants and the fuel consumption from eleven gasoline light-duty gasoline cars were studied, using the portable emission measurement system (PEMS). The results showed that the emission factors of light-duty gasoline cars were (910.4±822.6) mg/km for carbon monoxide (CO), (58.0±48.3) mg/km for nitrogen oxides (NO_x), and (21.6±16.1) mg/km for total hydrocarbons (THC), respectively. The emission rates of CO, NO_x, and THC increased with the increase of vehicle specific power-velocity (VSP-v), and the emissions in the cold start phase accounted for 11.2%±2.1%, 3.7%±5.4%, and 52.7%±4.6% of the total CO, NO_x, and THC mass, respectively. The transient fuel consumption rates of the light-duty gasoline cars increased with the increase of VSP-v. Vehicle relative fuel consumption increased significantly as the vehicle average speed was less than 15 km/h, and increased slightly as the vehicle average speed was over 40 km/h. The emission rates of CO, NO_x, and THC at 20 ℃ were higher than those at 1 ℃. Ambient temperature also dramatically influenced vehicle fuel consumption rate. Especially when the vehicle was running at high speed, the fuel consumption rate at 1 ℃ was 27.1%±24.5% higher than that at 20 ℃.
- light-duty vehicles /
- gaseous pollutants /
- fuel consumption /
- injection method /
- cold start /
- driving conditions /
- ambient temperature

HTML全文

图 1 车辆排放测试系统示意

Figure 1. Schematic diagram of vehicle emission test system

下载: 全尺寸图片幻灯片

图 2 微观运行模态下CO、NO_x和THC的排放速率

Figure 2. Emission rates of CO, NO_x, and THC under micro-operating mode

下载: 全尺寸图片幻灯片

图 3 GDI和PFI车冷启动阶段CO、NO_x和THC排放贡献

Figure 3. Emission contributions of CO, NO_x, and THC for GDI and PFI vehicles in cold start phase

下载: 全尺寸图片幻灯片

图 4 GDI和PFI车辆在微观运行模态下的平均油耗速率

Figure 4. Average fuel consumption rates in micro-operating modes for GDI and PFI vehicles

下载: 全尺寸图片幻灯片

图 5 车辆平均速度和相对油耗因子的相关性

Figure 5. Correlations between averaged vehicle speeds and relative fuel consumption

下载: 全尺寸图片幻灯片

图 6 微观运行模态下不同环境温度的平均油耗速率

Figure 6. Average fuel consumption rates in micro-operating modes under different ambient temperatures

下载: 全尺寸图片幻灯片

表 1 测试车辆基本信息

Table 1. Details of tested vehicles

车辆编号	品牌	生产年份	排放标准	后处理	行驶里程/(10³ km)	排量/L	整备质量/kg	额定功率 /kW	喷油方式
1#	别克	2006	国2	TWC	132	1.6	1220	78	PFI
2#	丰田	2012	国4	TWC	59	1.6	1300	90	PFI
3#	别克	2017	国5	TWC	58	1.5	1225	81	PFI
4#	别克	2015	国5	TWC	91	1.4	1430	103	PFI
5#	大众	2016	国5	TWC	105	1.6	1265	87	PFI
6#	大众	2014	国4	TWC	29	1.8	1600	118	GDI
7#	东风	2016	国5	TWC	73	1.2	1305	100	GDI
8#	本田	2018	国5	TWC	11	1.5	1205	96	GDI
9#	雪佛兰	2018	国5	TWC	51	1.5	1520		GDI
10#	福特	2012	国4	TWC	131	1.8	1340		PFI
11#	别克	2015	国4	TWC	118	2.4	1595		PFI

下载: 导出CSV

表 2 测试车辆在不同道路上的行驶里程和平均速度

Table 2. Mileage and average speed of tested vehicles on different roads

车辆编号	道路类型	行驶里程/km	平均速度/(km/h)	车辆编号	道路类型	行驶里程/km	平均速度/(km/h)
1#	城市道路	15.2	21	7#	城市道路	15.1	35
	市郊道路	15.1	57		市郊道路	15.1	82
	高速路	15.1	82		高速路	15.1	100
2#	城市道路	15.2	13	8#	城市道路	15.1	38
	市郊道路	15.1	47		市郊道路	15.2	76
	高速路	15.3	82		高速路	15.1	102
3#	城市道路	15.1	18	9#	城市道路	15.1	36
	市郊道路	15.3	58		市郊道路	15.1	80
	高速路	15.2	68		高速路	15.1	102
4#	城市道路	15.2	28	10#	城市道路	15.2	27
	市郊道路	15.3	69		市郊道路	15.2	71
	高速路	15.2	94		高速路	15.3	85
5#	城市道路	15.2	19	11#	城市道路	15.3	19
	市郊道路	15.3	65		市郊道路	15.2	44
	高速路	15.2	62		高速路	15.1	80
6#	城市道路	15.1	17
	市郊道路	15.2	39
	高速路	15.1	81

下载: 导出CSV

表 3 轻型汽车Bin划分方法

Table 3. Bin distributions of light vehicles in this study

VSP/(kW/t)	v/(km/h)
VSP/(kW/t)	<1.6	1.6~40	40~80	≥80
≤−4	Bin1（怠速）	Bin11	Bin21	Bin35
−4~−2	Bin1（怠速）	Bin12	Bin22	Bin35
−2~0	Bin1（怠速）	Bin13	Bin23	Bin35
0~2	Bin1（怠速）	Bin14	Bin24	Bin35
2~4	Bin1（怠速）	Bin15	Bin25	Bin35
4~6	Bin1（怠速）	Bin16	Bin26	Bin36
6~8	Bin1（怠速）	Bin17	Bin27	Bin37
8~10	Bin1（怠速）	Bin18	Bin28	Bin38
10~12	Bin1（怠速）	Bin18	Bin29	Bin38
12~14	Bin1（怠速）	Bin18	Bin2X	Bin39
14~16	Bin1（怠速）	Bin18	Bin2Y	Bin39
16~20	Bin1（怠速）	Bin18	Bin2Y	Bin3X
>20	Bin1（怠速）	Bin18	Bin2Y	Bin3Y

下载: 导出CSV

表 4 本研究与其他研究气态污染物的排放因子

Table 4. Emission factors of gaseous pollutants from this study and other studies mg/km　

测试方法	CO	NO_x	THC	数据来源
车载测试	910.4±822.6	58.0±48.3	21.6±16.1	本研究
台架测试	983.2±114.8	30.9±47.2	40.6±45.1	文献[26]
台架测试	713.3±460.0	86.8±49.2	72.3±47.9	文献[27]
台架测试	375.9±98.6	21.9±15.4	54.5±25.5	文献[28]

下载: 导出CSV

参考文献(39)

[1]	IODICE P, SENATORE A. Appraisal of pollutant emissions and air quality state in a critical Italian region: methods and results[J]. Environmental Progress & Sustainable Energy,2015,34(5):1497-1505.
[2]	TONG Z M, CHEN Y J, MALKAWI A, et al. Energy saving potential of natural ventilation in China: the impact of ambient air pollution[J]. Applied Energy,2016,179:660-668. doi: 10.1016/j.apenergy.2016.07.019
[3]	DROZD G T, ZHAO Y L, SALIBA G, et al. Detailed speciation of intermediate volatility and semivolatile organic compound emissions from gasoline vehicles: effects of cold-starts and implications for secondary organic aerosol formation[J]. Environmental Science & Technology,2019,53(3):1706-1714.
[4]	生态环境部. 中国移动源环境管理年报[A]. 北京: 生态环境部, 2019.
[5]	MCCAFFERY C, ZHU H W, LI C G, et al. On-road gaseous and particulate emissions from GDI vehicles with and without gasoline particulate filters (GPFs) using portable emissions measurement systems (PEMS)[J]. Science of the Total Environment,2020,710:136366. doi: 10.1016/j.scitotenv.2019.136366
[6]	YANG Z W, LIU Y, WU L, et al. Real-world gaseous emission characteristics of Euro 6b light-duty gasoline- and diesel-fueled vehicles[J]. Transportation Research Part D:Transport and Environment,2020,78:102215. doi: 10.1016/j.trd.2019.102215
[7]	CHONG H S, KWON S, LIM Y, et al. Real-world fuel consumption, gaseous pollutants, and CO₂ emission of light-duty diesel vehicles[J]. Sustainable Cities and Society,2020,53:101925. doi: 10.1016/j.scs.2019.101925
[8]	GRAHAM L. Chemical characterization of emissions from advanced technology light-duty vehicles[J]. Atmospheric Environment,2005,39(13):2385-2398. doi: 10.1016/j.atmosenv.2004.10.049
[9]	SINGH S. Comparison of fuel economy and gaseous emissions of gas-direct injection versus port fuel injection light duty vehicles based on real-world measurements[D]. North Carolina: North Carolina State University, 2018.
[10]	王军方, 尹航, 王宏丽, 等.轻型汽油车国六标准可行性研究[J]. 环境工程技术学报,2017,7(6):661-665. doi: 10.3969/j.issn.1674-991X.2017.06.091 WANG J F, YIN H, WANG H L, et al. Study on probability of compliance with China 6 standard for the emission from light duty gasoline vehicles[J]. Iournal of Environmental Engineering Technology,2017,7(6):661-665. doi: 10.3969/j.issn.1674-991X.2017.06.091
[11]	ZHAO F, LAI M C, HARRINGTON D L. Automotive spark-ignited direct-injection gasoline engines[J]. Progress in Energy and Combustion Science,1999,25(5):437-562. doi: 10.1016/S0360-1285(99)00004-0
[12]	WEILENMANN M, FAVEZ J Y, ALVAREZ R. Cold-start emissions of modern passenger cars at different low ambient temperatures and their evolution over vehicle legislation categories[J]. Atmospheric Environment,2009,43(15):2419-2429. doi: 10.1016/j.atmosenv.2009.02.005
[13]	CLAIROTTE M, ADAM T W, ZARDINI A A, et al. Effects of low temperature on the cold start gaseous emissions from light duty vehicles fuelled by ethanol-blended gasoline[J]. Applied Energy,2013,102:44-54. doi: 10.1016/j.apenergy.2012.08.010
[14]	YAO Z L, WANG Q D, HE K B, et al. Characteristics of real-world vehicular emissions in Chinese cities[J]. Journal of the Air & Waste Management Association (1995),2007,57(11):1379-1386.
[15]	ZHANG S J, WU Y, LIU H, et al. Real-world fuel consumption and CO₂ (carbon dioxide) emissions by driving conditions for light-duty passenger vehicles in China[J]. Energy,2014,69:247-257. doi: 10.1016/j.energy.2014.02.103
[16]	YANG L, WU Y, LI J Q, et al. Mass concentrations and temporal profiles of PM₁₀, PM_2.5 and PM₁ near major urban roads in Beijing[J]. Frontiers of Environmental Science & Engineering,2014,9(4):675-684.
[17]	WU Y, ZHANG S J, LI M L, et al. The challenge to NO_x emission control for heavy-duty diesel vehicles in China[J]. Atmospheric Chemistry and Physics,2012,12(19):9365-9379. doi: 10.5194/acp-12-9365-2012
[18]	环境保护部, 国家质量监督检验检疫总局. 轻型汽车污染物排放限值及测量方法: GB 18352.6—2016[S]. 北京: 中国环境科学出版社, 2020.
[19]	LUJÁN J M, BERMÚDEZ V, DOLZ V, et al. An assessment of the real-world driving gaseous emissions from a Euro 6 light-duty diesel vehicle using a portable emissions measurement system (PEMS)[J]. Atmospheric Environment,2018,174:112-121. doi: 10.1016/j.atmosenv.2017.11.056
[20]	国家发展和改革委员会. 轻型汽车燃料消耗量试验方法: GB/T 19233—2003[S]. 北京: 中国标准出版社, 2003.
[21]	IMÉNEZ-PALACIOS J L. Understanding and quantifying motor vehicle emissions with vehicle specific power and TILDAS remote sensing[D]. Massachusetts: Massachusetts Institute of Technology, 1999.
[22]	杨柳含子. 基于车载诊断系统的机动车油耗与氮氧化物排放特征研究[D]. 北京: 清华大学, 2016: 20-23.
[23]	US Environmental Protection Agency. Development of emission rates for heavy-duty vehicles in the motor vehicle emissions simulator MOVES2010[R]. Washington DC: Office of Transportation and Air Quality, 2010: 11-12.
[24]	BISHOP G A, STEDMAN D H, BURGARD D A, et al. High-mileage light-duty fleet vehicle emissions: their potentially overlooked importance[J]. Environmental Science & Technology,2016,50(10):5405-5411.
[25]	BORKEN-KLEEFELD J, CHEN Y C. New emission deterioration rates for gasoline cars: results from long-term measurements[J]. Atmospheric Environment,2015,101:58-64. doi: 10.1016/j.atmosenv.2014.11.013
[26]	SALIBA G, SALEH R, ZHAO Y L, et al. Comparison of gasoline direct-injection (GDI) and port fuel injection (PFI) vehicle emissions: emission certification standards, cold-start, secondary organic aerosol formation potential, and potential climate impacts[J]. Environmental Science & Technology,2017,51(11):6542-6552.
[27]	WU X, ZHANG S J, GUO X, et al. Assessment of ethanol blended fuels for gasoline vehicles in China: fuel economy, regulated gaseous pollutants and particulate matter[J]. Environmental Pollution,2019,253:731-740. doi: 10.1016/j.envpol.2019.07.045
[28]	DARDIOTIS C, MARTINI G, MAROTTA A, et al. Low-temperature cold-start gaseous emissions of late technology passenger cars[J]. Applied Energy,2013,111:468-478. doi: 10.1016/j.apenergy.2013.04.093
[29]	MAHADEVAN G, SUBRAMANIAN S. Experimental investigation of cold start emission using dynamic catalytic converter with pre-catalyst and hot air injector on a multi cylinder spark ignition engine[C]//SAE Technical Paper Series. 400 Commonwealth Drive, Warrendale, PA, United States: SAE International, 2017.
[30]	WANG W, MCCOOL G, KAPUR N, et al. Mixed-phase oxide catalyst based on Mn-mullite (Sm, Gd) Mn₂O₅ for NO oxidation in diesel exhaust[J]. Science,2012,337:832-835. doi: 10.1126/science.1225091
[31]	CHAN T W, MELOCHE E, KUBSH J, et al. Impact of ambient temperature on gaseous and particle emissions from a direct injection gasoline vehicle and its implications on particle filtration[J]. SAE International Journal of Fuels and Lubricants,2013,6(2):350-371. doi: 10.4271/2013-01-0527
[32]	COLE R L, POOLA R B, SEKAR R. Exhaust emissions of a vehicle with a gasoline direct-injection engine[C]//SAE Technical Paper Series. 400 Commonwealth Drive, Warrendale, PA, United States: SAE International, 1998.
[33]	ZHU R C, HU J N, BAO X F, et al. Tailpipe emissions from gasoline direct injection (GDI) and port fuel injection (PFI) vehicles at both low and high ambient temperatures[J]. Environmental Pollution,2016,216:223-234. doi: 10.1016/j.envpol.2016.05.066
[34]	ZHENG X, WU Y, ZHANG S J, et al. Evaluating real-world emissions of light-duty gasoline vehicles with deactivated three-way catalyst converters[J]. Atmospheric Pollution Research,2018,9(1):126-132. doi: 10.1016/j.apr.2017.08.001
[35]	王军方, 丁焰, 王爱娟, 等.北京机动车行驶工况研究[J]. 环境工程技术学报,2012,2(3):240-246. doi: 10.3969/j.issn.1674-991X.2012.03.037 WANG J F, DING Y, WANG A J, et al. Study of vehicle driving cycle modes on road in Beijing[J]. Journal of Environmental Engineering Technology,2012,2(3):240-246. doi: 10.3969/j.issn.1674-991X.2012.03.037
[36]	National Research Council. Cost, effectiveness, and deployment of fuel economy technologies for light-duty vehicles[M]. Washington DC: National Academies Press, 2015.
[37]	CONFER K A, KIRWAN J, ENGINEER N. Development and vehicle demonstration of a systems-level approach to fuel economy improvement technologies[C]//SAE Technical Paper Series. 400 Commonwealth Drive, Warrendale, PA, United States: SAE International, 2013.
[38]	KOBAYASHI S, PLOTKIN S, RIBEIRO S K. Energy efficiency technologies for road vehicles[J]. Energy Efficiency,2009,2(2):125-137. doi: 10.1007/s12053-008-9037-3
[39]	GONZÁLEZ PALENCIA J C, FURUBAYASHI T, NAKATA T. Energy use and CO₂ emissions reduction potential in passenger car fleet using zero emission vehicles and lightweight materials[J]. Energy,2012,48(1):548-565. □ doi: 10.1016/j.energy.2012.09.041